LI Haihong,HAO Jian *.Anodic Oxidation of Aluminum Alloy with Citric Acid-Sulfuric Acid and Its Properties[J].Plating & Finishing,2022,(2):20-25.[doi:10.3969/j.issn.1001-3849.2022.02.005]
铝合金柠檬酸-硫酸阳极氧化及性能研究
- Title:
- Anodic Oxidation of Aluminum Alloy with Citric Acid-Sulfuric Acid and Its Properties
- 关键词:
- 柠檬酸 - 硫酸阳极氧化; 阳极氧化膜; 电压; 显微硬度; 耐腐蚀性能
- 分类号:
- TQ153.6
- 文献标志码:
- A
- 摘要:
- 以 2024 铝合金做基体进行柠檬酸 - 硫酸阳极氧化，研究了电压对柠檬酸阳极氧化膜的微观形貌、成分、厚度、显微硬度和耐腐蚀性的影响，并分析了柠檬酸在阳极氧化中的作用机理。结果表明：添加柠檬酸使电解液对阳极氧化膜的腐蚀溶解作用减弱，提高了成膜效率并且有利于阳极氧化膜较均匀溶解，从而提高致密度和性能。随着电压升高（ 8~22 V ），柠檬酸阳极氧化膜的孔洞尺寸增大且结构有所改变，致密度、厚度和显微硬度都呈先增加后降低的趋势，耐腐蚀性能先逐步提高而后下降，但电压对柠檬酸阳极氧化膜成分影响不大。电压 18 V 制备的柠檬酸阳极氧化膜厚度达 15.0 μ m 且孔隙率仅为 9.4 % ，承受外加载荷的能力较强，同时能有效阻止腐蚀进一步发展，因此具有更高的显微硬度（ 192.4 HV ）和良好的耐腐蚀性能，其低频阻抗值达到 20.6 k Ω ·cm 2 ，腐蚀失重仅为 0.85 mg/cm 2 。该柠檬酸阳极氧化膜的致密度和性能明显好于相同电压下制备的硫酸阳极氧化膜。
- Abstract:
- Anodic oxidation of 2024 aluminum alloy with citric acid-sulfuric acid was carried out ， the effects of voltage on the microstructure ， components ， thickness ， microhardness and corrosion resistance of the anodic oxide films were studied ， and the action mechanism of citric acid in anodic oxidation was also analyzed. The results showed that the addition of citric acid weakened the corrosion a nd dissolution of anodic oxidation film in the electrolyte ， which improved the film-formation efficiency and was conducive to the uniform dissolution of anodic oxidation film ， thus improved its compactness and properties. With the increase of voltage from 8 V to 22 V ， the pore size of citric acid anodic oxidation film increased and the structure of pores changed. Moreover ， the compactness ， thickness and microhardness increased first and then decreased ， and the corrosion resistance improved gradually and then weakened. However ， voltage had little effect on the components of citric acid anodic oxidation film. The citric acid anodic oxidation film obtained at 18 V had the maximum thickness about 15.0 μ m and the lowest porosity of 9.4 % and its ability to bear external load was strong and could effectively prevent further development of corrosion. Therefore ， it exhibited higher microhardness （ 192.4 HV ） and good corrosion resistance ， the low frequency impedance reached 20.6 k Ω ·cm 2 and the corrosion weight loss was only 0.85 mg/cm 2 . The compactness and properties of the citric acid anodic oxidation film were obviously better than that of the sulfuric acid anodic oxidation film obtained at the same voltage.
参考文献/References:
[1] 钱建才 , 邹洪庆 , 方敏 , 等 . 铝合金阳极氧化膜防护性能及失效规律研究 [J]. 装备环境工程 , 2019, 16(3): 58-62.
Qian J C, Zou H Q, Fang M, et al. Protective performance and failure behavior on anodized aluminum alloy[J]. Equipment Environmental Engineering, 2019, 16(3): 58-62 (in Chinese).
[2] Gong A, Zheng Y, Yang Z K, et al. Spray fabrication of superhydrophobic coating on aluminum alloy for corrosion mitigation [J]. Materials Today Communications, 2021, (26): 101828.
[3] 冉红锋 , 肖将楚 , 朱毅 . 铝合金盘基片化学镀镍缺陷的形成机理 [J]. 中国表面工程 , 2018, 31(3): 97-107.
Ran H F, Xiao J C, Zhu Y. Defect formation mechanism of electroless nickel plating on aluminum alloy disk [J]. China Surface Engineering, 2018, 31(3): 97-107 (in Chinese).
[4] Lin B L, Xu YY, Tian B. Effect of phosphating technologies on corrosion resistance of phosphate coatings on 6063 aluminum alloy [J]. Advanced Materials Research, 2011, (399-401): 2079-2082.
[5] 刘佳 . 3005 铝合金在有机 - 无机混合酸体系中阳极氧化工艺及其性能探究 [D]. 长沙 : 湖南大学 , 2015.
[6] 何潘亮 , 沈士泰 , 卫国英 . 硫酸 - 有机酸混合酸体系中铝合金硬质氧化膜的研究 [J]. 电镀与环保 , 2017, 37(6): 25-28.
He P L, Shen S T, Wei G Y. Investigation on hard anodic oxidation of aluminium alloy in sulfuric acid-organic acid mixed acid system [J]. Electroplating & Pollution Control, 2017, 37(6): 25-28 (in Chinese).
[7] 许玉玲 . 阳极氧化工艺对 7075 铝合金氧化膜性能影响的研究 [D]. 成都 : 西南交通大学 , 2016.
[8] Watcharenwong A, Saijaioup N, Bailuang Y, et al. Morphology and wettability of nanoporous aluminium oxide film prepared by anodization [J]. Key Engineering Materials, 2017, (737): 174-178.
[9] 黄燕滨 , 仪忠源 , 卢天虎 , 等 . 硫酸铈改性磷酸 - 硫酸铝合金阳极氧化膜耐腐蚀性研究 [J]. 电镀与涂饰 , 2014, 33(16): 681-684.
Huang Y B, Yi Z Y, Lu T H, et al. Study on corrosion resistance of cerous sulfate modified phosphoric-sulfuric acid anodic oxide coating on aluminum alloy [J]. Electroplating & Finishing, 2014, 33(16): 681-684 (in Chinese).
[10] 阳建君 , 王博文 , 陈天鸥 , 等 . 2A96 铝合金表面阳极氧化及性能研究 [J]. 包装学报 , 2019, 11(5): 16-23.
Yang J J, Wang B W, Chen T O, et al. Study on anodizing and properties of 2A96 aluminum alloy surface [J]. Packaging Journal, 2019, 11(5): 16-23 (in Chinese).
[11] Yu S W, Wang L S, Wu C G, et al. Studies on the corrosion performance of an effective and novel sealing anodic oxide coating [J]. Journal of Alloys and Compounds, 2020, (817): 153257.
[12] Wang R X, Wang L S, He C Y, et al. Studies on the sealing processes of corrosion resistant coatings formed on 2024 aluminium alloy with tartaric-sulfuric anodizing [J]. Surface and Coatings Technology, 2019, (360): 369-375.
相似文献/References:
[1]祁怀伟*,吴心元,王亮兵,等.6061铝合金阳极氧化膜的抗霉菌研究[J].电镀与精饰,2020,(11):39.[doi:10.3969/j.issn.1001-3849.2020.11.0080]
QI Huaiwei*,WU Xinyuan,WANG Liangbing,et al.Study on the Anti-Mold Performance of 6061Aluminum Alloy Anodic Oxidation Film[J].Plating & Finishing,2020,(2):39.[doi:10.3969/j.issn.1001-3849.2020.11.0080]
[2]王宏智,吴心元,吕成斌,等.3A21铝合金本色阳极氧化膜的抗霉菌研究[J].电镀与精饰,2021,(7):52.[doi:10.3969/j.issn.1001-3849.2021.07.010]
WANG Hongzhi,WU Xinyuan,LYU Chengbin,et al.Study on the Antifungal Activity of 3A21 Aluminum Alloy Anodic Oxidation Film[J].Plating & Finishing,2021,(2):52.[doi:10.3969/j.issn.1001-3849.2021.07.010]
[3]郭绍福,赵春红*.植酸封孔对铝制件阳极氧化膜耐蚀性的影响[J].电镀与精饰,2021,(8):6.[doi:10.3969/j.issn.1001-3849.2021.08.002]
GUO Shaofu,ZHAO Chunhong*.Effect of Phytic Acid Sealing on Corrosion Resistance of Anodic Oxidation Film on Aluminum Parts[J].Plating & Finishing,2021,(2):6.[doi:10.3969/j.issn.1001-3849.2021.08.002]
[4]骆 骢,马 硕*.无铬封闭处理对ZL101A铝合金阳极氧化膜耐蚀性能的影响[J].电镀与精饰,2022,(2):46.[doi:10.3969/j.issn.1001-3849.2022.02.010]
LUO Cong,MA Shuo *.Effect of Chromium-Free Sealing Treatment on Corrosion Resistance of Anodic Oxide Films on ZL101A Aluminum Alloy[J].Plating & Finishing,2022,(2):46.[doi:10.3969/j.issn.1001-3849.2022.02.010]
[5]吴姗姗,于瑾佳*,刘历波.铈盐封孔对建筑铝合金阳极氧化膜耐蚀性的影响[J].电镀与精饰,2022,(4):1.[doi:10.3969/j.issn.1001-3849.2022.04.001]
WU Shanshan,YU Jinjia*,LIU Libo.Effect of Cerium Salt Sealing on Corrosion Resistance of Anodic Oxide Film on Architectural Aluminum Alloy[J].Plating & Finishing,2022,(2):1.[doi:10.3969/j.issn.1001-3849.2022.04.001]
[6]高培云.锆盐封孔对建筑铝合金阳极氧化膜耐蚀性能的影响[J].电镀与精饰,2022,(5):44.[doi:10.3969/j.issn.1001-3849.2022.05.008]
GAO Peiyun.Effect of Zirconium Salt Sealing on Corrosion Resistance of Anodic Oxide Film on Aluminium Alloy Used in Construction[J].Plating & Finishing,2022,(2):44.[doi:10.3969/j.issn.1001-3849.2022.05.008]
[7]成张佳宁,黄坤坤.建筑铝合金表面制备耐久性超疏水阳极氧化膜[J].电镀与精饰,2022,(6):16.[doi:10.3969/j.issn.1001-3849.2022.06.004]
CHENG Zhangjianing,HUANG Kunkun.Preparation of Durable Super-Hydrophobic Anodic Oxide Film on Aluminum Alloy for Construction[J].Plating & Finishing,2022,(2):16.[doi:10.3969/j.issn.1001-3849.2022.06.004]
[8]王臻卓.电力设备材料酒石酸阳极氧化及其腐蚀行为研究[J].电镀与精饰,2022,(6):26.[doi:10.3969/j.issn.1001-3849.2022.06.006]
WANG Zhenzhuo.Study on Tartaric Acid Anodic Oxidation of Electrical Equipment Materials and Its Corrosion Behavior[J].Plating & Finishing,2022,(2):26.[doi:10.3969/j.issn.1001-3849.2022.06.006]
[9]邱小云,王冀恒. 铝合金阳极氧化膜沸水-稀土盐双重封闭及力学性能研究 [J].电镀与精饰,2022,(7):30.[doi:10.3969/j.issn.1001-3849.2022.07.006]
QIU Xiaoyun,WANG Jiheng.Dual Sealing of Anodic Oxidation Film on Aluminum Alloy with Boiling Water and Rare Earth Salt and Mechanical Properties[J].Plating & Finishing,2022,(2):30.[doi:10.3969/j.issn.1001-3849.2022.07.006]
[10]王薇薇.稀土铈对建筑铝材表面阳极氧化膜腐蚀防护性能的影响?/div>[J].电镀与精饰,2022,(11):59.[doi:10.3969/j.issn.1001-3849.2022.11.011]
WANG Weiwei.Effect of Rare Earth Cerium on Corrosion Protection of Anodic Oxidation Film on Surface of Construction Aluminum[J].Plating & Finishing,2022,(2):59.[doi:10.3969/j.issn.1001-3849.2022.11.011]
备注/Memo
收稿日期： 2021-05-08 修回日期： 2021-06-08 作者简介： 李海宏（ 1986 —），女，硕士，讲师， email ： li_hong126@163.com 通信作者： 郝健（ 1987 —），女，博士，副教授，研究方向：功能材料， email ： haojian2017@126.com 基金项目： 宁夏自治区自然科学基金项目（ 2018AAC03022 ）