[1]吴志宇,李杏清*,旷玉丹,等.三维电解处理含镍废水的研究[J].电镀与精饰,2022,(5):39-43.[doi:10.3969/j.issn.1001-3849.2022.05.007]
　WU Zhiyu,LI Xingqing*,KUANG Yudan,et al.Study on the Treatment of Nickel-Containing Wastewater by Three-Dimensional Electrolysis[J].Plating & Finishing,2022,(5):39-43.[doi:10.3969/j.issn.1001-3849.2022.05.007]
点击复制

三维电解处理含镍废水的研究()

《电镀与精饰》[ISSN:1001-3849/CN:12-1096/TG]

卷:
期数:
2022年5
页码:
39-43
栏目:
出版日期:
2022-05-16

文章信息/Info

Title:
Study on the Treatment of Nickel-Containing Wastewater by Three-Dimensional Electrolysis
作者:
吴志宇; 李杏清*; 旷玉丹; 黎建平
（深圳市世清环保科技有限公司，广东 深圳 518105）
Author(s):
WU Zhiyu;  LI Xingqing*;  KUANG Yudan;  LI Jianping
（Shenzhen S-King Environmental Protection Technology Co.， Ltd.， Shenzhen 518105， China）
关键词:
含镍废水; 三维电解; 化学需氧量; 降解率; 稳定性
Keywords:
nickel-containing wastewater;  three-dimensional electrolysis;  chemical oxygen demand;  degradation rate;  stability
分类号:
X703.1
DOI:
10.3969/j.issn.1001-3849.2022.05.007
文献标志码:
A
摘要:
以含镍废水为研究对象，石墨极板为阴阳极，负载氧化性的活性炭为填料，底部连接曝气装置，构建三维电解体系。利用单因素分析的方法和正交实验的分析方法分别对三维电解体系的电压、初始 pH 以及电解时间进行了考察。通过计算化学需氧量（ COD ）的降解率，研究了体系在不同条件下的作用效果，分析了活性炭在该三维电解体系的稳定性。结果表明，该三维电解体系的最佳工艺参数为：电压 17.5 V 、初始 pH 7 、电解时间 3 h ，在此条件下 COD 的去除率达到 94.02% ；三个因素对三维电解体系的影响顺序为：电压 >pH> 电解时间，同时证明活性炭在该体系中有非常好的稳定性，可以重复利用。
Abstract:
： In this paper ， nickel-containing wastewater is used as the research object ， the graphite plate is the cathode and anode ， the oxidizing activated carbon is the filler ， and the bottom is connected with an aeration device to construct a three-dimensional electrolysis system. Single factor analysis and the orthogonal experiment analysis were used to investigate the voltage ， initial pH value and electrolysis time of the three-dimensional electrolysis system. By calculating the degradation rate of chemical oxygen demand （ COD ）， the effect of the system under different conditions was studied ； and the stability of activated carbon in the three-dimensional electrolysis system was investigated. The results show that the optimal process parameters of the three-dimensional electrolysis system are voltage 17.5 V ， initial pH 7 and electrolysis time 3 h. Under these conditions ， the removal rate of COD reaches 94.02%. The influence order of three factors on three-dimensional electrolysis system is ： voltage > pH > electrolysis time. At the same time ， it is proved that activated carbon has very good stability in the system and can be reused.

参考文献/References:



[1] 严永华 , 杜鹃 , 吴晓琴 . 羰基镍中毒 [J]. 职业卫生与应急救援 , 2002, 20(4): 221-223.

[2] 邵刚 . 含镍废水处理与回收技术 [J]. 重庆环境保护 , 1985(4): 37-39, 36.

[3] 苏宏智 . 水体富营养化及其防治 [J]. 文摘版 : 工程技术 , 2015(11): 160.

[4] Mergili M, muller J P, Schneider J F. Spatio-temporal development of high-mountain lakes in the headwaters of the Amu Darya River(Central Asia)[J]. Global and Planetary Change, 2013, 107: 13-24.

[5] Kure S, Jang S, Ohara N, et al. Hydrologic impact of regonal climate change for the snow-fed and glacier-fed river basins in the Republic of Tajikistan : statistical downscaling of global climate model projections[J]. Hydrological Processes, 2013, 27(26): 4071-4090.

[6] Bijmans M F M, Helvoort P J V, Dar S A, et al. Selective recovery of nickel over iron from a nickel-iron solution using microbial sulfate reduction in a gas-lift bioreactor[J]. Water Research, 2009, 43(3): 853-861.

[7] 王亮 . 电镀铜镍废水化学处理工艺的优化研究 [D]. 哈尔滨 : 哈尔滨工业大学 , 2014.

[8] 陈武 . 三维电极处理几种模拟有机废水研究 [D]. 武汉 : 华中科技大学 , 2007.

[9] Polcaro A M, Palmas S, Renoldi F, et al. Three-dimentional electrodes for the electrochemical combustion of origanic pollutants[J]. Electrochimica Acta, 2000, 46(14): 389-394.

[10] Geng M, Zhou Z. Progress on treatment of cyanide wastewater[J]. Guangdong Chemical Industry, 2010, 121(Pt):483-499.

[11] 国家环境保护总局 . HJ/T 399 — 2007 水质化学需氧量的测定快速消解分光光度计法 [S]. 北京 : 中国环境科学出版社 , 2008.

[12] 刘瑞江 , 张业旺 , 闻崇炜 , 等 . 正交试验设计和分析方法研究 [J]. 实验技术与管理 , 2010, 27(9): 52-55.

相似文献/References:

[1]张 卫*.电镀含镍废水处理工艺优化研究[J].电镀与精饰,2021,(10):41.[doi:10.3969/j.issn.1001-3849.2021.10.008]
　ZHANG Wei*.Study on Treatment Process and Optimization of Nickel-Containing Electroplating Wastewater[J].Plating & Finishing,2021,(5):41.[doi:10.3969/j.issn.1001-3849.2021.10.008]
[2]张 博,李金花,周保学*,等.镀镍废水的资源化回收利用[J].电镀与精饰,2021,(10):46.[doi:10.3969/j.issn.1001-3849.2021.10.009]
　ZHANG Bo,LI Jinhua,ZHOU Baoxue*,et al.Resource Recovery and Utilization of Nickel Plating Wastewater[J].Plating & Finishing,2021,(5):46.[doi:10.3969/j.issn.1001-3849.2021.10.009]
[3]王延梅.臭氧法处理电镀含镍废水工艺研究[J].电镀与精饰,2022,(1):45.[doi:10.3969/j.issn.1001-3849.2022.01.008]
　WANG Yanmei.Study on Treatment of Electroplating Wastewater Containing Nickel by Ozone[J].Plating & Finishing,2022,(5):45.[doi:10.3969/j.issn.1001-3849.2022.01.008]
[4]孙 超*,王德强,李晓艺.过硫酸钠氧化法处理电镀含镍废水工艺研究[J].电镀与精饰,2023,(7):101.[doi:10.3969/j.issn.1001-3849.2023.07.013]
　Sun Chao*,Wang Deqiang,Li Xiaoyi.Study on treatment of nickel containing electroplating wastewater by sodium persulfate oxidation[J].Plating & Finishing,2023,(5):101.[doi:10.3969/j.issn.1001-3849.2023.07.013]
[5]苗侨伟,王晓丽,刘军海 *,等. 硫酸亚铁-过硫酸钾体系深度处理含镍废水 [J].电镀与精饰,2023,(10):97.[doi:10.3969/j.issn.1001-3849.2023.10.016]
　Miao Qiaowei,Wang Xiaoli,Liu Junhai *,et al.Deep treatment of nickel-containing wastewater with ferrous sulfate- potassium persulfate system[J].Plating & Finishing,2023,(5):97.[doi:10.3969/j.issn.1001-3849.2023.10.016]
[6]沈 剑,秦 佩*,吴晓伟,等.含镍废水树脂在线回用系统工艺设计及应用[J].电镀与精饰,2024,(10):103.
　Shen Jian,Qin Pei*,Wu Xiaowei,et al.Process design and application of resin online reuse system for nickel containing wastewater[J].Plating & Finishing,2024,(5):103.

备注/Memo

备注/Memo:
收稿日期： 2021-06-06 修回日期： 2021-10-28 作者简介： 吴志宇（ 1988 ―），男，硕士，中级工程师， email ： 605459434@qq.com 通信作者： 李杏清， email ： 1968548710@qq.com
更新日期/Last Update: 2022-05-14