ZHANG Siwan*,ZHANG Jianguo,ZHANG Congzheng.Anti-corrosion Treatment of Q390E Steel for Special Equipment[J].Plating & Finishing,2021,(6):1-5.[doi:10.3969/j.issn.1001-3849.2021.06.001]
特种设备用Q390E钢防腐蚀处理研究
- Title:
- Anti-corrosion Treatment of Q390E Steel for Special Equipment
- Keywords:
- anti-corrosion special equipment Q390E steel corrosion morphology manganese phosphating treatment
- 文献标志码:
- A
- 摘要:
- 采用锰系磷化工艺对特种设备用Q390E钢进行防腐蚀处理，将不同浓度的PTFE乳液分别加入磷化液中，在Q390E钢表面制备了锰系磷化膜和三种锰系复合磷化膜。测试了锰系磷化膜和三种锰系复合磷化膜的电化学阻抗谱，并表征了锰系磷化膜和三种锰系复合磷化膜盐雾试验前后的表面形貌。结果表明：与Q390E钢相比，锰系磷化膜和三种锰系复合磷化膜的电荷转移电阻和溶液电阻都不同程度增大，对电荷转移及腐蚀介质扩散具有较强的阻碍。锰系磷化膜和三种锰系复合磷化膜盐雾试验前后的表面形貌未发生显著变化，都能较好地保护Q390E钢，起到防腐蚀作用。磷化液中PTFE乳液浓度对锰系复合磷化膜的耐蚀性能有较大影响，PTFE乳液浓度为20 mL/L时制备的锰系复合磷化膜对Q390E钢能起到更好的防腐蚀作用，而PTFE乳液浓度太低或过高时制备的锰系复合磷化膜对Q390E钢的防腐蚀作用不太理想。
- Abstract:
- Manganese phosphating process was used for the anti-corrosion treatment of Q390E steel for special equipment. PTFE emulsion with different concentration was added to the phosphating solution respectively, and manganese phosphating film and three manganese composite phosphating films were prepared on the surface of Q390E steels. The electrochemical impedance spectra of manganese phosphating film and three manganese composite phosphating films were measured and the surface morphology before and after salt spray test were characterized. The results showed that compared with Q390E steel, the charge transfer resistance and solution resistance of manganese phosphating film and three manganese composite phosphating films were increased, which had strong obstacles to the charge transfer and diffusion of corrosive media. The surface morphology of manganese phosphating film and three manganese composite phosphating films did not change significantly before and after salt spray test, indicating that both of them could play an role in the anti-corrosion of Q390E steel. The concentration of PTFE emulsion in the phosphating solution had a great influence on the corrosion resistance of manganese composite phosphating film. When the concentration of PTFE emulsion was 20 mL/L, the manganese composite phosphating film can play a better anti-corrosion effect for Q390E steel. However, when the concentration of PTFE emulsion was too low or too high, the anti-corrosion effect of manganese composite phosphating film for Q390E steel was not ideal.
参考文献/References:
[1] 曾正明. 机械工程材料手册[M]. 北京: 机械工业出版社, 2009.
[2] 孙毓韬, 李树白, 李雪莲. 海工装备用Q390E钢表面腐蚀防护实验研究[J]. 电镀与环保, 2017, 37(6): 33-35.
Sun Y T, Li S B, Li X L. Experimental research on surface corrosion protection of Q390E steel for ocean engineering equipment[J]. Electroplating & Pollution Control,2017, 37(6): 33-35 (in Chinese).
[3] 张鹏飞. 不同表面处理工艺对高强螺栓钢组织及性能的影响[D]. 成都: 西南交通大学, 2017.
[4] 刘新院, 张宝亮, 张学文, 等. 合金钢黑色磷化膜研制及耐蚀性研究[J]. 电镀与精饰, 2014, 36(1): 32-35.
Liu X Y, Zhang B L, Zhang X W, et al. Alloy steel black phosphating film preparation and corrosion resistance[J]. Plating & Finishing, 2014, 36(1): 32-35 (in Chinese).
[5] Borko K, Pastorek F, Jackova M N, et al. Electrochemical properties of welded S355J2 steel before and after surface treatment by manganese phosphating[J]. Materials Today: Proceedings, 2018, 5(13): 26482-26488.
[6] Duszczyk J, Siuzdak K, Klimczuk T, et al. Manganese phosphatizing coatings: the effects of preparation conditions on surface properties[J]. Materials (Basel), 2018, 11(12): 2585-2594.
[7] 卢帅, 郭昭, 齐海东, 等. 占空比对脉冲电镀Zn-Ni-Mn合金镀层的影响[J]. 电镀与精饰, 2017, 39(11): 1-4.
Lu S, Guo Z, Qi H D, et al. Effect of duty cycle on Zn-Ni-Mn alloy coating prepared by pulse electroplating[J]. Plating & Finishing, 2017, 39(11): 1-4 (in Chinese).
[8] 邹忠利, 王北平, 马金福, 等. AZ31B镁合金氧化石墨烯掺杂钇盐转化膜耐蚀性研究[J]. 表面技术, 2018, 47(2): 164-170.
Zou Z L, Wang B P, Ma J F, et al. Corrosion resistance of graphene oxide-doped yttrium salt conversion coating on AZ31B magnesium alloy[J]. Surface Technology, 2018,47(2): 164-170 (in Chinese).
[9] Jiang G R, Zhou J, Shang T, et al. Corrosion resistance of Zn-Al-Mg alloys with hypoeutectic microstructure[J]. Solid State Phenomena, 2019, (198): 52-58.
[10] Zhou C, Tao M, Liu J, et al. Effects of interfacial interaction on corrosion resistance of polybenzoxazine/SiO2 nanocomposite coatings[J]. ACS Applied Polymer Materials, 2019, 1(3): 381-391.
[11] 陈金秋, 吴志生, 崔超, 等.深冷温度对AZ31镁合金CMT焊接接头耐蚀性的影响[J]. 稀有金属材料与工程,2018, 47(5): 1543-1549.
Chen J Q, Wu Z S, Cui C, et al. Effect of cryogenic treatment temperature on corrosion resistance of AZ31 magnesium alloy CMT weld joint[J]. Rare Metal Materials and Engineering, 2018, 47(5): 1543-1549 (in Chinese).
[12] 赵利民, 王树凤. 齿轮用45钢锰系磷化膜和锰系复合磷化膜的性能比较[J]. 电镀与精饰, 2020, 42(8): 13-17.
Zhao L M, Wang S F. Comparison of properties of manganese phosphating film and manganese composite phosphating film on 45 steel for gear[J]. Plating & Finishing, 2020, 42(8): 13-17 (in Chinese).
相似文献/References:
[1]李俊辉*,杨国华,宋铁创,等.钢制电缆桥架防腐蚀试验研究[J].电镀与精饰,2021,(5):49.[doi:10.3969/j.issn.1001-3849.2021.05.008]
LI Junhui*,YANG Guohua,SONG Tiechuang,et al.Anti-Corrosion Study of Steel Cable Bridge[J].Plating & Finishing,2021,(6):49.[doi:10.3969/j.issn.1001-3849.2021.05.008]
备注/Memo
收稿日期： 2020-10-24；修回日期： 2020-12-03
作者简介： 张思婉（1983—）， 硕士， 讲师， email： annable_990@163.com
基金项目： 河南省科技厅重点研发与推广专项（192102210162）