Wang Xinhui,Hao Jianjun*,Mu Shihui,et al.Effect of lanthanum nitrate on corrosion resistance of passivation film on zinc aluminum magnesium alloy[J].Plating & Finishing,2023,(1):23-27.[doi:10.3969/j.issn.1001-3849.2023.01.004]
硝酸镧对锌铝镁合金表面钝化膜耐蚀性的影响
- Title:
- Effect of lanthanum nitrate on corrosion resistance of passivation film on zinc aluminum magnesium alloy
- Keywords:
- passive film ; lanthanum nitrate ; corrosion resistance
- 分类号:
- TG174.45
- 文献标志码:
- A
- 摘要:
- 为解决锌铝镁钢板的耐蚀性问题，以硝酸镧作为稀土添加剂在其表面制备丙烯酸树脂 - 硅烷 - 稀土钝化膜层。采用扫描电子显微镜、 X 射线衍射光谱分析、电化学工作站、中性盐雾试验等方法，研究了不同硝酸镧添加量对钝化膜结构及耐蚀性的影响。结果表明，钝化膜以堆积方式沉积到基材表面，硝酸镧添加量为 0.5% 时，耐盐雾试验时间可达到 72 h ，腐蚀电流密度降低至 1.11×10 -6 A·cm -2 ，相较于基体降低了两个数量级，耐黑变性良好。
- Abstract:
- ： In order to solve the problem of corrosion resistance of zinc-aluminum-magnesium steel sheet ， an acrylic resin-silane-rare earth passivation film was prepared on its surface using lanthanum nitrate as a rare earth additive. The effects of different amounts of lanthanum nitrate on the structure and corrosion resistance of passive film were studied by means of scanning electron microscope ， X-ray diffraction spectrum analysis ， electrochemical workstation and neutral salt spray test. The results show that the passivation film is deposited on the surface of the substrate in a stacking manner. When the addition of lanthanum nitrate is 0.5% ， the corrosion resistance can reach NSST/72 h ， the corrosion current density reduced to 1.11×10 -6 A·cm -2 ， which is two orders of magnitude lower than that of the matrix ， and the blackening resistance is good.
参考文献/References:
[1] 小松 , 厚志 , 泉谷 , 等 . 溶融 Zn-Al-Mg 系合金 めっき 鋼板 の 促進腐食環境下 における 耐食性 と 防食機構 [J]. 鐵 と 鋼 : 日本鐡鋼協會 々 誌 , 2000, 86(8): 534-541.
[2] 吴晓晓 , 孔纲 , 车淳山 , 等 . 热浸镀锌 - 铝层表面镧盐转化工艺 [J]. 电镀与涂饰 , 2015, 34(11): 621-625.
[3] Hernández-Barrios C A, Saavedra J A, Higuera S L, et al. Effect of cerium on the physicochemical and anticorrosive features of TEOS-GPTMS sol-gel coatings deposited on the AZ31 magnesium alloy[J]. Surfaces and Interfaces, 2020, 21:100671.
[4] Rodic P, Milosev I. The influence of additional salts on corrosion inhibition by cerium(III) acetate in the protection of AA7075-T6 in chloride solution[J]. Corrosion Science, 2019, 149: 108-122.
[5] 李会芬 , 邹忠利 , 李春龙 . 镀锌层表面无铬钝化工艺的研究进展 [J]. 材料保护 , 2021, 54(3): 137-143.
[6] 单凤君 , 齐国超 , 王双红 , 等 . 热镀铝锌钢表面环氧树脂 - 硅烷复合涂层及其耐蚀性能 [J]. 材料保护 , 2013, 46(12): 7-9.
[7] Morimoto Y, Honda K, Nishimura K, et al. Excellent corrosion-resistant Zn-Al-Mg-Si alloy hot-dip galvanized steel sheet "SUPER DYMA"[J]. Nippon Steel Technical Report, 2003, 87(87): 22-24.
[8] 西村 , 一実 , 新頭 , 等 . 溶融 Zn-Mg めっき 鋼板 の 耐食性 [J]. 鐵 と 鋼 : 日本鐡鋼協會 々 誌 , 2003, 89(1): 174-179.
[9] 张世欢 . 锌铝镁镀层汽车板应用分析 [J]. 世界有色金属 , 2020(13): 167-168.
[10] 张海良 , 段武兵 , 汤亮 . 锌铝镁合金镀层高强度高耐腐蚀性能桥梁缆索技术应用研究 [J]. 金属制品 , 2020, 46(4):31-37.
[11] 李辛庚 , 赵芃 , 张晋梅 . 输变电工程钢构件热喷涂锌铝镁稀土合金防腐涂层技术经济性分析 [J]. 科技创新与应用 , 2016 (31): 36.
[12] Liu J, Wang D, Gao L, et al. Synergism between cerium nitrate and sodium dodecylbenzenesulfonate on corrosion of AA5052 aluminium alloy in 3 wt.% NaCl solution[J]. Applied Surface Science, 2016, 389: 369-377.
[13] Dan Z, Jie S, Zhang L, et al. Corrosion behavior of rare earth cerium based conversion coating on aluminum alloy[J]. Journal of Rare Earths, 2010, 28: 371-374.
[14] Aballe A, Bethencourt M, Botana F J, et al. CeCl 3 and LaCl 3 binary solutions as environment-friendly corrosion inhibitors of AA5083 Al-Mg alloy in NaCl solutions[J]. Journal of Alloys and Compounds, 2001, 323: 855-858.
[15] Milosev I, Rodic P. Cerium chloride and acetate salts as corrosion inhibitors for aluminum alloy AA7075-T6 in sodium chloride solution[J]. Corrosion, 2016, 72(8): 1021-1034.
[16] Milosev I, Volaric B. Conversion coatings based on rare earth nitrates and chlorides for corrosion protection of aluminum alloy 7075-T6[J]. Corrosion, 2017, 73(7): 822-843.
[17] Zhou B, Wei X, Wang Y, et al. Effect of lanthanum addition on microstructures and corrosion behavior of ZnAl-LDHs film of 6061 aluminum alloys[J]. Surface and Coatings Technology, 2019, 379: 125056.
[18] Toorani M, Aliofkhazraei M, Golabadi M, et al. Effect of lanthanum nitrate on the microstructure and electrochemical behavior of PEO coatings on AZ31 Mg alloy[J]. Journal of Alloys and Compounds, 2017, 719: 242-255.
[19] 袁美蓉 , 卢锦堂 , 孔纲 , 等 . 热镀锌层上硅酸盐膜的耐蚀性和自愈性 [J]. 材料工程 , 2012(6): 48-53.
[20] 许满足 , 邹忠利 . 成膜温度对镁合金镧盐转化膜耐蚀性的影响 [J]. 材料保护 , 2021, 54(4): 90-93.
[21] 甘树坤 , 吕雪飞 . 铜合金表面硝酸镧稀土钝化膜的性能研究 [J]. 材料保护 , 2008, 41(8): 35-37.
[22] 孔纲 , 刘仁彬 , 卢锦堂 , 等 . 热镀锌表面镧盐转化膜生长机理的研究 [J]. 金属学报 , 2010, 46(4): 487-493.
相似文献/References:
[1]黎恒君,郝建军*. 硅烷偶联剂对热镀锌铝镁板钝化膜耐蚀性的影响 [J].电镀与精饰,2023,(5):90.[doi:10.3969/j.issn.1001-3849.2023.05.013]
Li Hengjun,Hao Jianjun*.Effect of silane coupling agent on corrosion resistance of passivation film on hot dip galvanized aluminum magnesium sheet[J].Plating & Finishing,2023,(1):90.[doi:10.3969/j.issn.1001-3849.2023.05.013]
[2]郭 蓓,王利华,王宁涛,等. 2系铝合金三价铬钝化法研究进展 [J].电镀与精饰,2023,(6):48.[doi:10.3969/j.issn.1001-3849.2023.06.008]
Guo Bei,Wang Lihua,Wang Ningtao,et al.Research progress of trivalent chromium passivating method for 2 series aluminum alloys[J].Plating & Finishing,2023,(1):48.[doi:10.3969/j.issn.1001-3849.2023.06.008]
[3]宋乙峰,王悦鼎,岳重祥*,等.表面膜层对镀锡板表面张力及印铁缩孔的影响[J].电镀与精饰,2023,(12):8.[doi:doi ： 10.3969/j.issn.1001-3849.2023.12.002]
Song Yifeng,Wang Yueding,Yue Chongxiang*,et al.Effect of surface films on surface tension of tinplate and shrinkage hole during printing?/html>[J].Plating & Finishing,2023,(1):8.[doi:doi ： 10.3969/j.issn.1001-3849.2023.12.002]
[4]李积鹏,姚 莹*,刘小华,等.无铬耐指纹热镀铝锌钢板黑斑缺陷研究[J].电镀与精饰,2024,(2):87.[doi:10.3969/j.issn.1001-3849.2024.02.012]
Li Jipeng,Yao Ying*,Liu Xiaohua,et al.Study on black spot defect of chromium-free fingerprint-resistant hot-dip aluminized zinc steel plate[J].Plating & Finishing,2024,(1):87.[doi:10.3969/j.issn.1001-3849.2024.02.012]
[5]焦 莎,等.doi: 10.3969/j.issn.1001-3849.2025.01.005 氯化钾镀锌层表面不同颜色钝化膜的结构及耐蚀性分析[J].电镀与精饰,2025,(01):29.
Wang Shuaixing*,Du Nan.Microstructure and corrosion resistance analysis of different colored passive films on the surface of zinc coating obtained from potassium chloride system Jiao Sha1, 2, Liu Yan1, 2, Zhang Xiaobin1, 2, Zhang Tao3, Zhao Chao3,[J].Plating & Finishing,2025,(1):29.
备注/Memo
收稿日期： 2022-03-23 修回日期： 2022-04-12 作者简介： 王薪惠（ 1994 ―），女，硕士研究生， email ： 2023397746@qq.com * 通信作者： 郝建军， email ： hjj68881@163.com?/html>