Liu Kun,Zou Zhongli*,Xu Manzu,et al.Preparation and properties of praseodymium salt conversion film on AZ31B magnesium alloy[J].Plating & Finishing,2023,(1):39-45.[doi:10.3969/j.issn.1001-3849.2023.01.007]
AZ31B镁合金表面镨盐转化膜的制备及性能研究
- Title:
- Preparation and properties of praseodymium salt conversion film on AZ31B magnesium alloy
- Keywords:
- praseodymium nitrate ; magnesium alloy ; chemical conversion method ; corrosion resistance
- 分类号:
- TQ174.4
- 文献标志码:
- A
- 摘要:
- 稀土盐化学转化法是一种改善 AZ31B 镁合金耐蚀性能的有效方法。本文选用化学转化技术，将硝酸镨作为转化液的主要物质，在 AZ31B 镁合金表面生成不同程度的微米级镨盐转化膜层，利用电化学测试技术、析氢实验和点滴实验评价不同膜层的耐蚀性。结合扫描电镜、 X 射线衍射仪、能谱仪和 X 射线光电子能谱探究镨盐转化膜的表观形貌和组成结构。结果表明：镁合金表面生成一层致密膜层，膜层的主要组成元素为 Pr 和 O ，主要构成物质是氢氧化镨和镨的部分氧化物。当 Pr （ NO 3 ） 3 ·6H 2 O 质量浓度为 18 g·L -1 时，制备的膜层表面裂纹缺陷较少，较为光滑致密，试样的耐蚀性能最佳，自腐蚀电流密度相比镁合金试样下降了 4 个数量级，自腐蚀电位相比镁合金试样正移了大约 800 mV ，电化学交流阻抗谱同样显示该试样的电荷转移电阻和膜层电阻最大，相对于其他试样有了显著提升。
- Abstract:
- ： Rare earth salt chemical conversion method is an effective method to improve the corrosion resistance of AZ31B magnesium alloy. In this experiment ， the chemical conversion technology was selected. Praseodymium nitrate was used as the main substance of the conversion solution to form different degrees of micron-scale praseodymium salt conversion film on the surface of AZ31B magnesium alloy. The apparent morphology and structure of praseodymium salt conversion film were studied by scanning electron microscope ， X-ray diffraction ， energy dispersive spectrometer and X-ray photoelectron spectroscopy. The results show that a dense film is formed on the surface of magnesium alloy. The main components of the film are Pr and O ， and the main components are praseodymium hydroxide and some oxides of praseodymium. When the mass concentration of Pr （ NO 3 ） 3 ·6H 2 O is 18 g·L -1 ， the prepared film surface has fewer crack defects ， is relatively smooth and dense ， and the corrosion resistance of the sample is the best. The self-corrosion current density is 4 orders of magnitude lower than that of magnesium alloy sample ， and the self-corrosion potential moves forward by about 800 mV as compared with the magnesium alloy sample. The electrochemical AC impedance spectra also show that the charge transfer resistance and film resistance of this sample are the largest ， which is significantly improved compared with other samples.
参考文献/References:
[1] 曾爱平 , 薛颖 , 钱宇峰 , 等 . 镁合金的化学表面处理 [J]. 腐蚀与防护 , 2000(2): 55-56, 63.
[2] 杨雨云 . 镁合金新型稀土转化膜性能及机理研究 [D]. 哈尔滨 : 哈尔滨工程大学 , 2012.
[3] 王明 , 邵忠财 , 仝帅 . 镁合金表面处理技术的研究进展 [J]. 电镀与精饰 , 2013, 35(6): 15-20.
[4] 王向荣 . AZ91D 镁合金无铬化学转化膜的性能 [J]. 电镀与涂饰 , 2020, 39(23): 1643-1647.
[5] 周衡志 , 王珏 , 白允强 , 等 . 铈单盐浓度对 AZ91 镁合金表面稀土转化膜的影响 [J]. 材料保护 , 2019, 52(5): 64-67, 90.
[6] 甘树坤 , 刘爽 , 吕雪飞 . 金属表面耐蚀性稀土转化膜的研究进展 [J]. 吉林化工学院学报 , 2017, 34(9): 79-83.
[7] 王继敏 , 陈琳 , 王宁宁 , 等 . 时效对 AZ63 镁合金稀土镧 - 铈转化膜耐孔蚀性能的影响 [J]. 材料保护 , 2013,46(8): 12-14, 27-28.
[8] 张丽丽 , 王桂香 , 董国君 , 等 . 镁合金双稀土转化膜及其耐蚀性能的研究 [J]. 材料保护 , 2008, 41(12): 1-4, 88.
[9] 邹忠利 , 薛同 , 陈炜晔 , 等 . 成膜时间对 AZ31B 镁合金 Mn-Y 转化膜的影响 [J]. 稀土 , 2019(2): 104-112.
[10] 崔永辉 , 李学田 , 戴诗行 , 等 . 镁合金表面 Ce-Mn 和 Ce-Mo 复合转化膜性能的研究 [J]. 电镀与环保 , 2019, 39(1): 59-62.
[11] 崔作兴 , 戴诗行 , 邵忠财 . 不同添加剂对镁合金锡酸盐转化膜耐蚀性的影响 [J]. 电镀与环保 , 2019(3): 45-48.
[12] 陈东初 , 吴建锋 , 梁奕清 , 等 . 添加剂作用下制备环境友好型铈基镁合金稀土转化膜 [J]. 中国有色金属学报 ( 英文版 ), 2011, 21(8): 1905-1910.
[13] 崔学军 , 平静 , 窦宝捷 , 等 . 几种添加剂作用的微弧氧化膜表面结构及防腐性能 [J]. 中国表面工程 , 2018, 149(2): 45-56.
[14] Saket M, Amini R, Kardar R, et al. The chemical treatment of the AZ31-Magnesium alloy surface by a high-performance corrosion protective praseodymium (III)-based film[J]. Materials Chemistry and Physics, 2021, 260: 124113.
[15] Sarma D D, Rao C N R. XPES studies of oxides of second-and-third-row transition metals including rare earths[J]. Journal of Electron Spectroscopy & Related Phenomena, 1980, 20(1):25-45.
[16] Yang Y, Li Z Y, Yu Y. et al. Understanding enhancing mechanism of Pr 6 O 11 and Pr(OH) 3 in methanol electrooxidation[J]. Journal of Rare Earths, 2022, 40(1): 85-92.
[17] Sahar Z A, Masoud S N, Masoud H. Praseodymium oxide nanostructures: novel solvent-less preparation, characterization and investigation of their optical and photocatalytic properties[J]. RSC Advances, 2015, 5(43): 33792-33800.
[18] Yu Xiujin, Lin Bingyu, Lin Jianxin, et al. A novel fused iron catalyst for ammonia synthesis promoted with rare earth gangue[J]. Journal of Rare Earths, 2008(5): 711-716.
[19] Park J M, Kim H J, Kim S, et al. Luminescence property of rare-earth doped bismuth-borate glasses[J]. Procedia Engineering, 2012, 32: 855-861.
[20] Rudd A L, Breslin C B, Mansfeld F. The corrosion protection afforded by rare earth conversion coatings applied to magnesium[J]. Corrosion Science, 2000, 42(2): 275-288.
[21] 李玲莉 , 杨雨云 , 崔秀芳 , 等 . 酸根离子对镨盐化学转化膜的组成及性能的影响 [J]. 中国表面工程 , 2013, 26(1): 51-56.
[22] 李玲莉 , 杨雨云 , 赵刚 , 等 . 镁合金表面钇盐化学转化膜的制备与表征 [J]. 哈尔滨工程大学学报 , 2012, 33(12): 1553-1558.
[23] 许满足 , 邹忠利 . 成膜温度对镁合金镧盐转化膜耐蚀性的影响 [J]. 材料保护 , 2021, 54(4): 90-93, 117.
[24] 邹忠利 , 王田宇 , 薛同 , 等 . 钇掺杂对镁合金表面硅烷膜性能的影响 [J]. 电镀与涂饰 , 2020, 39(5): 269-272.
[25] 王雷 , 林经武 , 李晓 , 等 . AZ31 镁合金铈转化膜在 NaCl 溶液中的腐蚀性研究 [J]. 热加工工艺 , 2018, 47(4): 150-154, 163.
[26] Hinton B, Arnott D R, Ryan N E. Cerium conversion coatings for the corrosion protection of aluminium.[J]. Materials Forum, 1986, 9(3): 162-173.
[27] 宋光铃 . 镁合金腐蚀与防护 [M]. 北京 : 化学工业出版社 , 2006.
相似文献/References:
[1]徐美玲,亢淑梅,陈婷婷,等.添加氯化铈对镁合金Ni?P化学镀镀层性能影响[J].电镀与精饰,2019,(1):37.[doi:10.3969/j.issn.1001-3849.2019.01.008]
XU Meiling,KANG Shumei,CHEN Tingting,et al.Properties of Electroless Plating Ni?P on Magnesium AlloySubstrate by Adding CeCl3[J].Plating & Finishing,2019,(1):37.[doi:10.3969/j.issn.1001-3849.2019.01.008]
[2]牟世辉,尹鸿鹍,代肇一.镀铜优化对AZ91D镁合金疏水膜性能的影响[J].电镀与精饰,2019,(6):29.[doi:10.3969/j.issn.1001-3849.2019.06.006]
MU Shihui,YIN Hongkun,DAI Zhaoyi.Effect of Copper Plating Optimization on the Performance of AZ91D Magnesium Alloy Hydrophobic Membrane[J].Plating & Finishing,2019,(1):29.[doi:10.3969/j.issn.1001-3849.2019.06.006]
[3]刘 玮,安成强*,郝建军,等.钼酸钠对AZ91D镁合金钒/锆复合转化膜性能的影响[J].电镀与精饰,2019,(8):10.[doi:10.3969/j.issn.1001-3849.2019.08.003]
LIU Wei,AN Chengqiang*,HAO Jianjun,et al.Effect of Na2MoO4 on Properties of Vanadium/Zirconate Conversion Coating on AZ91D Magnesium Alloy[J].Plating & Finishing,2019,(1):10.[doi:10.3969/j.issn.1001-3849.2019.08.003]
[4]李佳霖,郝建军,牟世辉.Fe2+对镁合金电化学磷化改性研究[J].电镀与精饰,2019,(10):1.[doi:10.3969/j.issn.1001-3849.2019.10.001]
LI Jialin,HAO Jianjun,MOU Shihui.Study on Electrochemical Phosphating Modification of Magnesium Alloy by Fe2+[J].Plating & Finishing,2019,(1):1.[doi:10.3969/j.issn.1001-3849.2019.10.001]
[5]贾启华,许晓娟*.沉积时间对镁合金化学镀镍的影响[J].电镀与精饰,2019,(12):1.[doi:10.3969/j.issn.1001-3849.2019.12.001]
JIA Qihua,XU Xiaojuan*.Effect of Deposition Time on Direct Electroless Plating of Magnesium Alloys[J].Plating & Finishing,2019,(1):1.[doi:10.3969/j.issn.1001-3849.2019.12.001]
[6]王 丽,顾 威,郭 荣,等.环保型无机缓蚀剂对AZ91D镁合金的缓蚀效果[J].电镀与精饰,2020,(4):18.[doi:10.3969/j.issn.1001-3849.2020.04.0040]
WANG Li,GU Wei,GUO Rong,et al.Inhibition Effect of Environmental Protection Inorganic Corrosion Inhibitor on AZ91D Magnesium Alloy[J].Plating & Finishing,2020,(1):18.[doi:10.3969/j.issn.1001-3849.2020.04.0040]
[7]党在清*.镁合金复合镀层的制备及其结构与性能表征[J].电镀与精饰,2020,(11):16.[doi:10.3969/j.issn.1001-3849.2020.11.0040]
DANG Zaiqing*.Study on the Structure and Properties of Composite Coating on Magnesium Alloy[J].Plating & Finishing,2020,(1):16.[doi:10.3969/j.issn.1001-3849.2020.11.0040]
[8]王晓奇*,曹 慧,雷 彪.镁合金表面电弧离子镀TiAlN薄膜的结构与性能研究[J].电镀与精饰,2021,(6):25.[doi:10.3969/j.issn.1001-3849.2021.06.006]
WANG Xiaoqi*,CAO Hui,LEI Biao.Structure and Properties of TiAlN Films by Arc Ion Plating on Mg Alloys[J].Plating & Finishing,2021,(1):25.[doi:10.3969/j.issn.1001-3849.2021.06.006]
[9]宋政伟*,丁莉峰,王沛霖,等.镁合金表面Ni-P/Cu-Zn超疏水复合涂层制备及耐蚀性研究[J].电镀与精饰,2021,(7):10.[doi:10.3969/j.issn.1001-3849.2021.07.002]
SONG Zhengwei*,DING Lifeng,WANG Peilin,et al.Preparation and Corrosion Resistance of Ni-P/Cu-Zn Super-Hydrophobic Composite Coating on the Surface of Mg Alloy[J].Plating & Finishing,2021,(1):10.[doi:10.3969/j.issn.1001-3849.2021.07.002]
[10]牟世辉*,李鑫宇.恒电流作用下AZ91D镁合金磷化膜生长研究[J].电镀与精饰,2021,(9):1.[doi:10.3969/j.issn.1001-3849.2021.09.001]
MU Shihui*,LI Xinyu.Growth of Phosphating Film on AZ91D Magnesium Alloy Under Constant Current[J].Plating & Finishing,2021,(1):1.[doi:10.3969/j.issn.1001-3849.2021.09.001]
备注/Memo
收稿日期： 2022-03-03 修回日期： 2022-04-29 作者简介： 刘坤（ 1995 —），男，硕士研究生， email ： 1042159397@qq.com * 通信作者： 邹忠利， email ： zouzhongli@126.com 基金项目： 宁夏自然科学基金项目（ 2020AAC03193 ）