ZHANG Wei*.Study on Treatment Process and Optimization of Nickel-Containing Electroplating Wastewater[J].Plating & Finishing,2021,(10):41-45.[doi:10.3969/j.issn.1001-3849.2021.10.008]
电镀含镍废水处理工艺优化研究
- Title:
- Study on Treatment Process and Optimization of Nickel-Containing Electroplating Wastewater
- 文献标志码:
- A
- 摘要:
- 采用H2O2/UV+Na2S沉淀法处理含镍废水，考察了H2O2加入量、破络反应时间、体系pH和Na2S加入量等因素对废水中镍离子浓度的影响，利用Design Expert8.0中Box-Behnken法进行响应面分析优化。最佳工艺条件为：H2O2加入量21.5 mL/L，破络反应时间26.2 min，pH=9.7，Na2S加入量为67 mg/L。在该条件下，处理后的废水镍离子浓度达到0.0897 mg/L，满足排放标准。
- Abstract:
- The nickel-containing wastewater was treated by H2O2/UV + Na2S precipitation method in this paper. The effects of H2O2 addition amount, detoxification reaction time, pH and Na2S addition amount on the concentration of nickel ion in wastewater were investigated. And the response surface analysis was optimized by Box-Behnken method in Design Expert 8.0. The optimum technological conditions were as follows: H2O2 dosage 21.5 mL/L, reaction time 26.2 min, pH 9.7 and Na2S dosage 67 mg/L. Under these conditions, the concentration of nickel ion in the treated wastewater was about 0.0897 mg/L, which met the discharge standard.
参考文献/References:
[1] 赵盈利, 谢洪勇, 陈卫东. 硫化钠沉淀法处理含镍废水[J]. 中国粉体技术, 2017, 23(4): 94-97.
Zhao Y L, Xie H Y, Chen W D. Experimental study on treatment of nickel wastewater with sodium sulfide [J]. China Powder Science and Technology, 2017, 23(4): 94-97 (in Chinese).
[2] 李小花, 郭崇武, 吴梅娟. 基于沉淀法的化学镀镍废水处理工艺[J]. 电镀与涂饰, 2018, 37(24): 1151-1154.
Li X H, Guo C W, Wu M J. Process for treatment of the wastewater discharged from electroless nickel plating production based on chelating precipitation[J]. Electroplating & Finishing, 2018, 37(24): 1151-1154 (in Chinese).
[3] 聂发辉, 刘荣荣, 张慧敏, 等. 工业废水中镍的去除与回收技术及相关研究进展[J]. 水处理技术, 2015, 41(11): 7-14.
Nie F H, Liu R R, Zhang H M, et al. Research advances of nickel removal and recycling from industrial wastewater[J]. Technology of Water Treatment, 2015, 41(11): 7-14 (in Chinese).
[4] Bulasarav K, Thakuria H, Uppaluri R, et al. Combinatorial performance characteristics of agitated nickel hypophosphite electroless plating baths [J]. Journal of Materials Processing Technology, 2011, 211(9): 1488-1499.
[5] 张厚, 施力匀, 杨春. 电镀废水处理技术研究进展[J]. 电镀与精饰, 2018, 40(2): 36-41.
Zhang H, Shi L Y, Yang C. Research progress of electroplating wastewater treatment technology[J]. Plating & Finishing, 2018, 40(2): 36-41 (in Chinese).
[6] Gorokhovsky A, Vikulova M, Escalante-Garcia J, et al. Utilization of nickel-electroplating wastewaters in manufacturing of photocatalysts for water purification[J]. Process Safety and Environmental Protection, 2020, 134(C): 208-216.
[7] 张崇华. 电镀废水治理技术综述[M]. 北京中国环境科学出版社, 1992: 1-98.
[8] 于志达. 电镀废水零排放技术的应用[J]. 中国新技术新产品, 2019, (13):106-107.
Yu Z D. Application of zero discharge technology of electroplating wastewater[J]. New Technology New Products of China, 2019, (13): 106-107 (in Chinese).
相似文献/References:
[1]张 博,李金花,周保学*,等.镀镍废水的资源化回收利用[J].电镀与精饰,2021,(10):46.[doi:10.3969/j.issn.1001-3849.2021.10.009]
ZHANG Bo,LI Jinhua,ZHOU Baoxue*,et al.Resource Recovery and Utilization of Nickel Plating Wastewater[J].Plating & Finishing,2021,(10):46.[doi:10.3969/j.issn.1001-3849.2021.10.009]
[2]吴志宇,李杏清*,旷玉丹,等.三维电解处理含镍废水的研究[J].电镀与精饰,2022,(5):39.[doi:10.3969/j.issn.1001-3849.2022.05.007]
WU Zhiyu,LI Xingqing*,KUANG Yudan,et al.Study on the Treatment of Nickel-Containing Wastewater by Three-Dimensional Electrolysis[J].Plating & Finishing,2022,(10):39.[doi:10.3969/j.issn.1001-3849.2022.05.007]
[3]孙 超*,王德强,李晓艺.过硫酸钠氧化法处理电镀含镍废水工艺研究[J].电镀与精饰,2023,(7):101.[doi:10.3969/j.issn.1001-3849.2023.07.013]
Sun Chao*,Wang Deqiang,Li Xiaoyi.Study on treatment of nickel containing electroplating wastewater by sodium persulfate oxidation[J].Plating & Finishing,2023,(10):101.[doi:10.3969/j.issn.1001-3849.2023.07.013]
[4]苗侨伟,王晓丽,刘军海 *,等. 硫酸亚铁-过硫酸钾体系深度处理含镍废水 [J].电镀与精饰,2023,(10):97.[doi:10.3969/j.issn.1001-3849.2023.10.016]
Miao Qiaowei,Wang Xiaoli,Liu Junhai *,et al.Deep treatment of nickel-containing wastewater with ferrous sulfate- potassium persulfate system[J].Plating & Finishing,2023,(10):97.[doi:10.3969/j.issn.1001-3849.2023.10.016]
[5]沈 剑,秦 佩*,吴晓伟,等.含镍废水树脂在线回用系统工艺设计及应用[J].电镀与精饰,2024,(10):103.
Shen Jian,Qin Pei*,Wu Xiaowei,et al.Process design and application of resin online reuse system for nickel containing wastewater[J].Plating & Finishing,2024,(10):103.
[6]王延梅.臭氧法处理电镀含镍废水工艺研究[J].电镀与精饰,2022,(1):45.[doi:10.3969/j.issn.1001-3849.2022.01.008]
WANG Yanmei.Study on Treatment of Electroplating Wastewater Containing Nickel by Ozone[J].Plating & Finishing,2022,(10):45.[doi:10.3969/j.issn.1001-3849.2022.01.008]
备注/Memo
收稿日期： 2020-11-09；修回日期： 2021-01-18
通信作者： 张卫（1984—），女，硕士，讲师，从事环境保护、水处理方面的研究。email：wkzhangwei10@163.com
基金项目： 山东省高等学校科研创新平台课题项目（2018YY035）