WANG Bo*,ZHAO Donghong,XU Xiaodong.Effect of Ultrasonic-Assisted Zinc-Manganese Phosphating Treatment on Morphology and Corrosion Resistance of 45 Steel Flange[J].Plating & Finishing,2020,(7):7-11.[doi:10.3969/j.issn.1001-3849.2020.07.0020]
超声波辅助锌-锰系磷化处理对45钢法兰形貌与耐腐蚀性能的影响
- Title:
- Effect of Ultrasonic-Assisted Zinc-Manganese Phosphating Treatment on Morphology and Corrosion Resistance of 45 Steel Flange
- 关键词:
- 法兰; 超声波辅助锌-锰系磷化处理; 形貌; 元素组成; 耐腐蚀性能
- 文献标志码:
- A
- 摘要:
- 为减轻45钢法兰表面锈蚀，对法兰进行锌-锰系磷化处理，并在磷化过程中辅助超声波震荡。表征了磷化处理后法兰的宏观形貌和微观形貌，分析了磷化膜表面元素组成，并测试了未经磷化处理法兰和磷化处理后法兰的耐腐蚀性能。结果表明：磷化处理后法兰呈均匀一致的深灰色，表面致密，晶粒呈棒状和条状。磷化膜的厚度约13.4 μm，元素组成主要为Zn、P、O和Mn，各元素在磷化膜中呈较均匀分布。磷化处理后法兰的耐腐蚀性能明显优于未经磷化处理法兰，盐雾试验48 h后，磷化处理后法兰的锈蚀面积较小，另外其腐蚀电位、腐蚀电流密度和低频区的阻抗值等指标也较好。
- Abstract:
- The 45 steel flange was treated by zinc-manganese phosphating assisted with ultrasonic vibration in order to reduce surface corrosion. The macro-morphology and micro-morphology of the flange after phosphating treatment were characterized, the elemental composition of the phosphating film was analyzed, and the corrosion resistance of the flange without phosphating treatment and the flange after phosphating treatment was tested. The results showed that the flange after phosphating treatment has a uniform appearance of dark gray, with dense surface structure and rod and strip grains. The phosphating film with a thickness of 13.4 μm was mainly composed of Zn, P, O and Mn, and each elements were evenly distributed in the phosphating film. The corrosion resistance of the flange after phosphating treatment was obviously better than that of the flange without phosphating treatment. After 48 h salt spray test, the corrosion area of the flange after phosphating treatment was smaller. In addition, the corrosion potential, corrosion current density and impedance value in the low-frequency zone of the flange after phosphating treatment were also better than that of the flange without phosphating treatment.
参考文献/References:
[1] 蒋贝尔. 法兰腐蚀和离心泵的腐蚀[J]. 山东工业技术, 2018, 4:26.
Jiang B E. Flange corrosion and centrifugal pump corrosion[J]. Shandong Industrial Technology, 2018, 4:26(in Chinese).
[2] 李立群, 曹永香, 唐庆平. 钢铁零件常温磷化工艺的研究[J]. 电镀与环保, 2019, 39(3):49-51.
Li L Q, Cao Y X, Tang Q P. Study on phosphating process for iron and steel parts at room temperature[J]. Electroplating and Pollution Control, 2019, 39(3):49-51(in Chinese).
[3] 胡贵芳, 胡秀英, 宋皖杰, 等. 超声波作用下钢铁常温磷化影响因素研究[J]. 电镀与精饰, 2019, 41(5):9-15.
Li L Q, Cao Y X, Tang Q P. Study on the influencing factors of phosphating for iron and steel under the action of ultrasound at room temperature[J]. Plating and Finishing, 2019, 41(5):9-15(in Chinese).
[4] 于海青, 丁春燕. 中温锌钙系磷化工艺在Q345钢防腐蚀中的应用[J]. 电镀与精饰, 2020, 42(5):44-48.
Yu H Q, Ding C Y. Application of medium temperature Zn-Ca phosphating process in corrosion protection of Q345 steel[J]. Plating and Finishing, 2020, 42(5):44-48(in Chinese).
[5] 赵大磊, 周游, 姚颖悟, 等. 一种常温锌镍锰系磷化液研究[J]. 电镀与精饰, 2013, 35(4):9-12.
Zhao D l, Zhou Y, Yao Y W, et al. A new Zn-Ni-Mn phosphating solution at room temperature[J]. Plating and Finishing, 2013, 35(4):9-12(in Chinese).
[6] 林自华. 钢铁复合化学转化膜高耐蚀性的探讨[J]. 电镀与环保, 2005, 25(2):29-30.
/ Lin Z H. A discussion on the high corrosion resistance of composite chemical conversion coatings on iron and steel[J]. Electroplating and Pollution Control, 2005, 25(2):29-30(in Chinese).
[7] 刘万青, 朱峰. 环保型磷化及磷化替代技术研究现状[J]. 家电科技, 2009, 7:28-29.
Liu W Q, Zhu F. Research status of environmental protection phosphating and phosphating alternative technology[J]. Home Appliance of Science and Technology, 2009, 7:28-29(in Chinese).
[8] Liang J, Srinivasan P B, Blawert C, et al. Influence of pH on the deterioration of plasma electrolytic oxidation coated AM50 magnesium alloy in NaCl solutions[J]. Corrosion Science, 2010, 52(2):540-547.
[9] 刘健, 曹磊, 万勇, 等. 硼掺杂DLC薄膜在海水环境中的腐蚀磨损性能[J]. 表面技术, 2019, 48(8):247-256.
Liu J, Cao L, Wan Y, et al. Corrosive wear properties of boron-doped diamond-like carbon films in seawater environment[J]. Surface Technology, 2019, 48(8):247-256(in Chinese).
[10] Cui M, Pu J, Zhang G, et al. The corrosion behaviors of multilayer diamond-like carbon coatings: Influence of deposition periods and corrosive medium[J]. RSC Advances, 2016, 6(34):28570-28578.
相似文献/References:
[1]吕 芳,谷 娜*.化工管道连接法兰磷化工艺条件优化及磷化膜的耐蚀性[J].电镀与精饰,2022,(3):59.[doi:10.3969/j.issn.1001-3849.2022.03.011]
LYU Fang,GU Na *.Optimization of Phosphating Process Conditions for Chemical Pipe Connection Flange and Corrosion Resistance of Phosphating Film[J].Plating & Finishing,2022,(7):59.[doi:10.3969/j.issn.1001-3849.2022.03.011]
备注/Memo
收稿日期： 2020-03-16；修回日期： 2020-03-26
通信作者： 王波，yangzhou_wang11@126.com
基金项目： 江苏省教育科学“十二五”规划2015年度职成教重点资助课题（B-a/2015/03/008）、扬州市校合作资金项目（YZ2016271）、扬州工业职业技术学院重点科研课题（2016xjzk004）